Contact Us

TEL : 86-571-87390575
Fax: 86-571-87390523
Address: Zhongce Garden, No.8 St, Hangzhou Eco And Tec Dev Zone, China

Home > News > Content
The Physical Properties Of Surgical Sutures.
May 06, 2018

Tensile strength

The U.S. national pharmacopoeia (USP) is defined as the minimum strength to pull a single suture. So tensile strength is a specific tension value, and a nonlinear interval. The effective tensile strength refers to the tensile strength of the suture wound or the knot. The tensile strength of the same suture is one third of its unknotted strength. In general, the suture of synthetic materials is stronger than that of the suture, and the tendons are stronger than those of synthetic materials.


Structure refers to a single strand (single strand) or multiple strands (braid). Many sutures are knitted. This suture is easy to operate but increases the chances of infection and tissue response. It is easy to cause infection because of its siphoning, which causes bacteria and foreign bodies to infiltrate. Bacteria deep inside the knitting line can escape from the host macrophages. Therefore, monofilament (nylon or polypropylene) is more suitable for stitching contaminated wounds. However, single wire is not easy to operate.

The coefficient of friction

The friction coefficient of the suture determines whether the stitching is easy to pass through the tissue. Sutures with low friction coefficient (such as polypropylene suture) can slip through tissue easily, so they are often used for leather sutures. The lower the friction coefficient, the smoother the suture and the easier the knot. Therefore, when using polypropylene suture, a few more knots are often required.

The knot is firm.

The line knot strength is the minimum pulling force that makes the knot loose, which is proportional to the friction coefficient of the suture. The greater the strength of the line, the less likely the wound will open. The friction coefficient is high in stitching, but it is difficult to use when passing through the skin.

The elastic

Elasticity refers to the ability of a suture to recover its length and form when the wound is swollen and elongated. Sutures with better elasticity (such as NovafilTM polybutadiene) are difficult to cut during tissue edema, and the edema is not loose after edema, and the wound is not easy to crack.